news and activities
What should be paid attention to in the running in period of new excavator

What should be paid attention to in the running in period of...

The new excavator or the overhauled excavator must pass through a period of trial operation, usually called the walking time. The aim of the walking is to prevent the early wear of the excavator and prolong the life of the excavator. The following provisions must be strictly enforced in the period of the excavator's closing period:

(1) in the execution period, the excavator should hang the sign of "walking in period" at the obvious place, so that the relevant personnel can pay attention to the provisions of the period of application, and take it off after the expiration of the term.

(2) running in period 30% engine speed reducer, load 20%-30% operation, no person shall dismantle the engine speed limiting device to be sealed after the expiration of the right under the supervision of technical personnel can be removed.

(3) the throttle is strictly prohibited when the engine is started. The engine should be preheated for 20-50 seconds at low temperature start, and then start immediately. When the engine starts to run for 3-5 minutes at idle speed, the speed and load can be increased when the cooling water temperature rises to 40 degrees.

(4) the technical preparation before engine start, the technical requirements during operation, and the technical work before and after the fire are carried out according to the general mechanical operation rules or the requirements of engine operation instructions.

(5) the excavator should excavate the looser soil in the first 30 or 50 hours of the running period. The loading capacity is 1/2 per time, and the load can increase gradually within 70 or 50 hours later, but it should not exceed 3/4 of the bucket capacity and reduce operation speed appropriately.

(6) during the running period, we should pay attention to the operation of various excavators, check the working temperature of bearings, gears and friction pairs, and observe whether there is leakage in hydraulic system. The abnormal phenomena in the operation should be stopped immediately to check the causes and be excluded.

(7) the working conditions of the excavator should be checked, adjusted and lubricated according to the running condition of the closing period. At the same time, check the cleaning of the gear box lubricating oil and hydraulic oil tank, and replace it when necessary.

leave a message
All rights reserved::Tai'an Jiahe Heavy Machinery Co., Ltd.   魯ICP備07017427號-6 Technical Support: Interplanetary Network
天天射天天干,天天爽夜夜爽夜夜爽精品视频,天天干夜夜操,天天操夜夜操泰安嘉和重工機械有限公司 汕头市晟发包装材料有限公司 江西省腾达食品有限公司 广州宏源纸品有限公司 飛天影院 三木影視影院 河北卓君影視傳媒有限公司 隨州市遠圖農業機械有限公司 順風影視 - 瀋陽順風電影網 臨海市華洲機械有限公司 株洲市冀禹水利機械有限責任公司 四平歐維姆機械有限公司 四川聞志影視有限公司 河北卓君影視傳媒有限公司 自貢中瑞機械製造有限公司 北京東方佳聯影視技術有限公司